ElectroMod Super Beetle
Description
Up for sale is a beautifully restored 1978 Super Beetle. Quicker, quieter and significantly more reliable than when new. Retains all the style but a lot more fun to drive! IMHO this is the past, present and future of classic cars. No modifications have been made to frame or body, all new parts have been bolted to existing mounting points.
The details of the EV conversion is as follows:
Motor - NetGain HyPer9 AC Motor X1 Controller 120 Volt - The 9 inch HyPer9 AC motor is based on a high efficiency design. The motor is a permanent magnet assisted synchronous reluctance design and holds the highest efficiency rating of IE4+ at 94% motor efficiency. The motor is IP56 sealed. The matching controller, an AC-X1 by SME Group will accept a supply side DC voltage of up to 132 Volts, and will output up to 760 Amps output, with a peak 88kW of power. The permanent magnets are a new design that are manufactured without the use of rare earth elements, but still gain a big efficiency advantage with a 173 lb/ft of torque.
Batteries – Sino Poly - 36X 200 aha Lithium Ion Battery for a 23kWh 115V battery system.. New batteries as opposed to recycled from a wrecked EV. For full specs see: https://canev.com/wp-content/uploads/sp200spec.pdf. Range is 160-180km depending on power setting chosen and how much fun you're having.
Transmission – Given the torque of the motor you very rarely have to use the clutch or shift gear. Tranny is remanufactured and configured specifically for electric vehicle. The stock gearing was replaced with two high quality forward gears set at a ratio specific to wheel/tire combo with 195/75/15 diameter. The reverse gear is eliminated as the AC motor has the ability to rotate either direction by simply toggling a switch.
Heater – yes it has heat that is both reliable and free of exhaust fumes - High Voltage Double Element Heater – Supplied by Can EV. The 3000 watt heater is designed for use in colder climates. Blower runs on 12V and comes with a 3 speed switch. The original VW heater channels, ductwork and, in dash fan are retained. The added heater has temperature limiting characteristics and self-regulate for energy efficiency.
Suspension/Brakes – refreshed, strengthened and stiffened. Top Line Parts was a helpful source of advice and parts. KYB shocks all round, heavy-duty billet sway bar clamps, Sport + Rally front springs, new front swing arms. Tires are P4s. Disk brakes installed prior to EV conversion, all pads and flex lines replace.
Asking $53,000 ONO or interesting part trade. Marc 778-585-8545
- Make: Volkswagen
- Model: Beetle
- Body Type: Convertible
- Color: Orange
- Year: 1978
- Kilometers: 63000
- Transmission: Other
- Ad Type: Offering
- For Sale By: Owner
- Trim: Karmann
- Drivetrain: Rear-wheel drive (RWD)
- No. of Doors: 2
- No. of Seats: 4
cars & vehicles | classic cars
2023-07-06